RESEARCH ARTICLE


Investigations on the Pozzolanic Effect of Sugar Cane Bagasse Ashes Used in Cementitious Composites



Paula G. Lamezon de Páduaa, *, Túlio H. Panzerab, Roberto B. Figueiredoc, A. M. Gomesc, Maria T. Paulino Aguilarc
a Department of Structural Engineering, Federal University of Minas Gerais, Belo Horizonte, Brazil
b Department of Mechanical Engineering, Centre for Innovation and Technology in Composite Materials, Federal University of São João Del Rei, Minas Gerais, São Paulo, Brazil
c Department of Materials and Construction Engineering, Federal University of Minas Gerais, Belo Horizonte, Brazil


Article Metrics

CrossRef Citations:
0
Total Statistics:

Full-Text HTML Views: 3721
Abstract HTML Views: 2011
PDF Downloads: 824
ePub Downloads: 636
Total Views/Downloads: 7192
Unique Statistics:

Full-Text HTML Views: 1685
Abstract HTML Views: 1018
PDF Downloads: 601
ePub Downloads: 457
Total Views/Downloads: 3761



Creative Commons License
© Lamezon de Pádua et al.; Licensee Bentham Open.

open-access license: This is an open access article licensed under the terms of the Creative Commons Attribution-Non-Commercial 4.0 International Public License (CC BY-NC 4.0) (https://creativecommons.org/licenses/by-nc/4.0/legalcode), which permits unrestricted, non-commercial use, distribution and reproduction in any medium, provided the work is properly cited.

* Address correspondence to this author at the Department of Structural Engineering, Federal University of Minas Gerais, Belo Horizonte, Brazil; E-mail: paulalamezon@hotmail.com


Abstract

Brazil is a major producer of alcohol from sugar cane, a fuel with low environmental impact. The production of alcohol generates a large amount of bagasse, the biggest waste of Brazilian agriculture. This bagasse is usually burned for energy production providing nearly 3% of residual ashes. The potential use of these ashes like mineral admixture of cementitious composites depends on calcination conditions. The present work identifies the physical and chemical characteristics of ashes from the furnace exhauster, obtained in an industry located at southeast region of Brazil. The ashes were obtained from bagasse of sugar cane harvest in two different seasons. Chemical composition analysis, X-ray diffraction, grain size distribution, loss on ignition, thermogravimetry analysis (TGA), differential scanning calorimetry (DSC), specific surface measurements (BET) and Fourier transform infrared spectroscopy (FTIR) tests were used to characterize the ashes. The pozzolanic activity was estimated by pozzolanic activity index tests with cement and lime, by the modified Chapelle test, electrical conductivity in lime solution tests, TGA and FTIR. The ashes presented different chemical compositions and degree of amorphicity. The ashes with a higher content of silica, the lower organic material content and high degree of crystallinity (1st harvest), for the same size, have higher pozzolanic on electrical conductivity in lime solution tests than the ashes with lower silica content and higher amorphicity (2nd harvest). However, the results of differential scanning calorimetry (DSC) and modified Chapelle method would indicate the pozzolanicity of the ashes of the 2nd harvest. The results of pozzolanic activity index (with cement or lime) indicated the ashes were not pozzolanic.

Keywords: Cementitious composites, Differential scanning calorimetry (DSC), Fourier transform infrared spectroscopy (FTIR), Modified chapelle, Physical-chemical characteristic, Pozzolanic activity, Sugar cane bagasse ash.